York CZF Manual de Instalação descarregar pdf

562156-UIM-A-0610

R-410A

OUTDOOR SPLIT-SYSTEM

AIR CONDITIONING

MODELS: 16 SEER - CZF / AC6B / AL6B SERIES

2 TO 5 TONS

INSTALLATION MANUAL

LISTED

ISO 9001

Certified Quality

Management System

TABLE OF CONTENTS

GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

UNIT INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

EVACUATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

ELECTRICAL CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . 5

SYSTEM CHARGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

INSTRUCTING THE OWNER . . . . . . . . . . . . . . . . . . . . . . . 11

AC CONTROL BOARD FUNCTIONALITY . . . . . . . . . . . . . 12

WIRING DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

LIST OF FIGURES

Typical Installation with Required Clearances . . . . . . . . . . . . 3

Tubing Hanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Underground Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Heat Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Typical Field Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Communications Harness Connection . . . . . . . . . . . . . . . . . . 6

CFM Selection Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Communicating AC with Communicating

Air Handler or Furnace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Communicating AC with Non-Communicating Air Handler

or Furnace using Communicating Interface Control . . . . . . . . 7

Thermostat Wiring – Single Stage Air Conditioner

(with AC control) – PSC Air Handler . . . . . . . . . . . . . . . . . . . . 8

Thermostat Wiring – Single Stage Air Conditioner

(with AC control) – VS Air Handler . . . . . . . . . . . . . . . . . . . . . 9

Thermostat Wiring – Single Stage Air Conditioner

(with AC control) – Modulating Furnace . . . . . . . . . . . . . . . . 10

Wiring Diagram (2 - 4 Ton) . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Wiring Diagram (5 Ton) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

LIST OF TABLES

R-410A Saturation Properties . . . . . . . . . . . . . . . . . . . . . . . . 12

TEST Input Functionality . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Operational Mode Display . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Status Code Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Operational Fault Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Sensor or Switch Fault Codes . . . . . . . . . . . . . . . . . . . . . . . 14

Wiring Related Fault Codes . . . . . . . . . . . . . . . . . . . . . . . . . 14

SECTION I: GENERAL

The outdoor units are designed to be connected to a matching indoor

coil with sweat connect lines. Sweat connect units are factory charged

with refrigerant for the highest sales volume evaporator plus 15 feet of

field supplied lines.

Matching indoor coils are available with a thermal expansion valve or

an orifice liquid feed sized for the most common usage. The orifice size

and/or refrigerant charge may need to be changed for some system

combinations, elevation differences, or total line lengths. See tabular

data sheet provided in unit literature packet for charge requirements.

Refer to Application Data covering “General Piping Recommendations

and Refrigerant Line Length” (Part Number 247077).

SECTION II: SAFETY

This is a safety alert symbol. When you see this symbol on

labels or in manuals, be alert to the potential for personal

injury.

Understand and pay particular attention to the signal words DANGER,

WARNING, or CAUTION.

DANGER indicates an imminently hazardous situation, which, if not

avoided, will result in death or serious injury

WARNING indicates a potentially hazardous situation, which, if not

avoided, could result in death or serious injury

CAUTION indicates a potentially hazardous situation, which, if not

avoided may result in minor or moderate injury

. It is also used to

alert against unsafe practices and hazards involving only property dam-

age.

1 2 3 4 5 6 ... 17 18

Resumo do Conteúdo

Página 1 - INSTALLATION MANUAL

562156-UIM-A-0610R-410AOUTDOOR SPLIT-SYSTEM AIR CONDITIONINGMODELS: 16 SEER - CZF / AC6B / AL6B SERIES2 TO 5 TONSINSTALLATION MANUALLISTEDISO 9001Cert

Página 2

562156-UIM-A-061010 Johnson Controls Unitary Products FIGURE 12: Thermostat Wiring – Single Stage Air Conditioner (with AC control) – Modulating Furna

Página 3 - MUST BE WEATHERPROOF

562156-UIM-A-0610Johnson Controls Unitary Products 11SECTION VI: SYSTEM CHARGE1. The factory charge in the outdoor unit includes enough charge forthe

Página 4

562156-UIM-A-061012 Johnson Controls Unitary Products3. If the coil needs to be cleaned, use clean water to wash dust, dirt,and debris from outdoor co

Página 5 - SECTION IV: EVACUATION

562156-UIM-A-0610Johnson Controls Unitary Products 13LED DIAGNOSTIC INDICATORSThe control includes two LED’s that display diagnostic information.LED1

Página 6 - CONTROL BOARD

562156-UIM-A-061014 Johnson Controls Unitary ProductsFAULT CODE DISPLAYThe control will display any fault code that is currently active using theLED’s

Página 7 - DEHUMIDIFICATION CONTROL

562156-UIM-A-0610Johnson Controls Unitary Products 15COOLING OPERATIONFirst-Stage Cooling OperationDuring first-stage cooling operation, the control w

Página 8

562156-UIM-A-061016 Johnson Controls Unitary ProductsSECTION IX: WIRING DIAGRAM FIGURE 13: Wiring Diagram (2 - 4 Ton)

Página 9

562156-UIM-A-0610Johnson Controls Unitary Products 17 FIGURE 14: Wiring Diagram (5 Ton)

Página 10 - 562156-UIM-A-0610

Página 11 - SECTION VI: SYSTEM CHARGE

562156-UIM-A-06102 Johnson Controls Unitary ProductsINSPECTIONAs soon as a unit is received, it should be inspected for possible dam-age during transi

Página 12 - FUNCTIONALITY

562156-UIM-A-0610Johnson Controls Unitary Products 3GROUND INSTALLATIONThe unit may be installed at ground level on a solid base that will notshift or

Página 13

562156-UIM-A-06104 Johnson Controls Unitary ProductsThe outdoor condensing unit must be connected to the indoor evapora-tor coil using field supplied

Página 14

562156-UIM-A-0610Johnson Controls Unitary Products 52. Remove the cap and Schrader core from both the liquid and vaporservice valve service ports at t

Página 15

562156-UIM-A-06106 Johnson Controls Unitary ProductsFIELD CONNECTIONS POWER WIRING1. Install the proper size weatherproof disconnect switch outdoors a

Página 16 - SECTION IX: WIRING DIAGRAM

562156-UIM-A-0610Johnson Controls Unitary Products 7CFM SELECTION BOARD SETTINGSFor proper system operation the CFM Selection Board jumpers must beset

Página 17

562156-UIM-A-06108 Johnson Controls Unitary ProductsFor additional connection diagrams for all UPG equipment refer to “Low Voltage System Wiring” docu

Página 18 - Norman, OK 73069

562156-UIM-A-0610Johnson Controls Unitary Products 9 FIGURE 11: Thermostat Wiring – Single Stage Air Conditioner (with AC control) – VS Air Handler09$

Comentários a estes Manuais

Sem comentários

York CZF Manual de Instalação

Consulte online ou descarregue Manual de Instalação para Aparelhos de ar condicionado "split system" York CZF. York CZF Installation manual Manual do Utilizador

Resumo do Conteúdo

Comentários a estes Manuais

Manuais e produtos relacionados com Aparelhos de ar condicionado "split system" York CZF